New! The On-Floor All-Weather ШТВ-1 and ШТВ-2 Cabinets with a Climate Control System

15.09.2017

Remer Production Group has been manufacturing the all-weather cabinets for many years. It is a known fact that over time the vendor becomes an expert in his field. Due to numerous requests of our customers, we have developed and introduced a ready solution at the beginning of this year: a climatic suspended telecommunication cabinet with a preinstalled power, heating and cooling system. This enabled our buyers avoiding time-consuming calculations of power supply and heat generation, input and output air flows. The companies stopped spending their time for the assembly, saved their money and obtained a reliable proven and certified product. The popularity of our out-of-the-box solution has confirmed that our decision to develop this area was correct; and today we offer our buyers the on-floor all-weather cabinets featuring the REM preinstalled climate control system. This is a ready solution allowing to cool the equipment inside a cabinet during the summer season and maintain a positive temperature in it during the winter season. The REM climate control system installed on the front door of the cabinet represents a conditioner with the power from 1000 to 2000W and a heater having the thermal output of 500-1000W.

1.jpg

2.jpg

The complete cabinets of ШТВ-1 and ШТВ-2 series are intended for placement of the standalone active and passive telecommunication equipment, they ensure protection from the environmental effects and unauthorized access as well as maintain the required temperature conditions of the inner space. The protection level ensured by the enclosure as per GOST 14254 is minimum IP54.

Two cable feed-through holes are provided for in the cabinet base. At the customer’s request, different number of feed-through holes of different diameters may be provided for in the framework bottom and in the wall between the sections (for ШТВ-2). The scope of supply comprises two cable entries with a M32 nut (MG32A-25G type), 10 rubber plugs for cable entry openings as well as the set for blocking the rear door from inside the cabinet.

The cabinets contain only the certified climatic equipment by the REM trademark as well as the European wiring components. It is important for us that the buyer gets a fully reliable fault-free solution for operation.

A wide range of accessories for the additional protection and operational maintenance convenience is provided for (additional 300 mm and 600 mm pedestals with maintenance doors, a roof with a sliding hood, a reinforced lock, and etc.).

3.jpg

4.jpg

The product is supplied from the 220 V 50 Hz AC power supply network. For the two-section ШТВ-2 cabinets, standby power supply may be connected through the 32A DEKraft socket (plug) of the ВЩ-102 series (or analog) from the external 220V 50Hz power supply source. 

5.jpg

The product has the 1st electric shock hazard protection category as per GOST 12.2.027.0-96. As regards the resistance against the external mechanical factors during operation, the cabinets correspond to the M1 group as per GOST 17516.1.

The product climatic category is У1 as per GOST 15150 and it is intended for the outdoor operation at the temperature from minus 50 to plus 45 °С and the relative air humidity of max. 80 % at 20 °С.

The admissible distributed static load is up to 800 kg.

The climate control system is supplied through the air separation unit.

6.jpg

The list of equipment to install

Name

Number (pcs.)

ШТВ-1/ШТВ-2

Air Separation Unit 

1/1

Door opening sensor

2/3

Generator plug

0/1

Cam switch

0/1

Feed-through terminals   

0/5

Earthing bus 

1/1


Composition of Air Separation Unit


Name

Number (pcs.)

Surge arrester 

1

Voltage indicator 

1

Eaton automatic switch

2

Eaton protective differential switch

1

Socket mountable on a DIN rail

1

Terminal clamps

8

Earthing stud

1

Earthing terminal

1


Design with the installed capacity (cooling/heating)

Model number

Conditioner power, W

Heater power, W

ШТВ-1-24.7.6-К3АА-ТК

1000

500

ШТВ-1-24.7.9-К3АА-ТК

1000

500

ШТВ-1-30.7.6-К3АА-ТК

1500

800

ШТВ-1-30.7.9-К3АА-ТК

1500

800

ШТВ-1-36.7.6-К3АА-ТК

2000

1000

ШТВ-1-36.7.9-К3АА-ТК

2000

1000


7.jpg

1.jpg

Model number

Conditioner power, W

Heater power, W

ШТВ-2-24.10.6-К3А3-ТК

1000

500

ШТВ-2-24.10.9-К3А3-ТК

1000

500

ШТВ-2-30.10.6-К3А3-ТК

1500

800

ШТВ-2-30.10.9-К3А3-ТК

1500

800

ШТВ-2-36.10.6-К3А3-ТК

2000

1000

ШТВ-2-36.10.9-К3А3-ТК

2000

1000

8.jpg

9.jpg

The cabinets were tested for compliance with the requirements of TR TS 004/2011, TR TS 020/2011, GOST 32127-2013, are provided with all the necessary certificates and available for order from our distributors.


Back